基于EDEM-FLUENT耦合的滚筒冷渣机颗粒轴向扩散运动
DOI:
作者:
作者单位:

作者简介:

通讯作者:

中图分类号:

TK229.6

基金项目:

四川省教育厅创新团队项目(17TD0026).2017年自贡市第三届“双千计划”资助项目。 2016年四川省科技成果转化项目(2017CC0046)


Research on Axial Diffusion Motion of Particles in Drum Slag Cooler Based on EDEM-FLUENT coupling
Author:
Affiliation:

Fund Project:

Innovation team project of Sichuan Provincial Education Department。Supported projects of the third "double thousand plan" of Zigong in 2017。Sichuan scientific and technological achievements transformation project in 2016

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    基于欧拉-拉格朗日、离散单元法理论,利用EDEM-FLUENT耦合方法,考虑了气相对颗粒的相互作用,以及颗粒与颗粒之间的碰撞,对滚筒冷渣机六棱形冷渣管料床中灰渣颗粒轴向扩散进行了数值模拟分析,得出了灰渣颗粒在填充度25%,颗粒滚落状态下的动态休止角θd=29°,安装倾斜角3°工况下,轴向扩散运动随滚筒转速n(5 r/min ~ 10 r/min)、颗粒粒径d(1.5 mm ~ 3.5 mm)的变化规律。实验结果表明:当粒径一定时,轴向扩散系数随着转速n的增大而增大,相比5 r/min转速,10 r/min转速下颗粒轴向扩散系数增大了23.6%;当滚筒转速一定时,轴向扩散系数随着粒径的增大而增大。粒径d从1.5 mm增加到3 mm及3.5 mm时,轴向扩散系数分别增大了3倍和7.06倍。轴向扩散系数越大,颗粒轴向运动就越剧烈,滚筒出力越强,炉渣处理效率越高。

    Abstract:

    Based on the theory of Euler Lagrange and discrete element method, EDEM-FLUENT coupling method is used to simulate the axial diffusion of ash particles in the hexagonal slag cooling pipe bed of drum slag cooler, considering the interaction between gas and particles and the collision between particles.In the filling fraction of the ash particles is 25%, the dynamic angle of repose is θd=29 °, and the installation tilt angle is 3 °, The change law of axial diffusion movement with speed(n=5 r/min-10 r/min)and particle size(d=1.5 mm-3.5 mm)is obtained.The experimental results show that when the particle size is constant, the axial diffusion coefficient increases with the increase of rotating speed n. compared with 5 r/min, the axial diffusion coefficient increases by 23.6% at 10 r/min; When the drum speed is constant, the axial diffusion coefficient increases with the increase of particle size. When the particle size d increases from 1.5 mm to 3 mm and 3.5 mm, the axial diffusion coefficient increases by 3 times and 7.06 times respectively. The greater the axial diffusion coefficient, the more intense the axial movement of particles, the stronger the drum output, and the higher the slag treatment efficiency.

    参考文献
    相似文献
    引证文献
引用本文

赖镜安,何庆中,王佳,等. 基于EDEM-FLUENT耦合的滚筒冷渣机颗粒轴向扩散运动[J]. 科学技术与工程, 2022, 22(3): 1004-1010.
Lai Jingan, He Qingzhong, Wang Jia, et al. Research on Axial Diffusion Motion of Particles in Drum Slag Cooler Based on EDEM-FLUENT coupling[J]. Science Technology and Engineering,2022,22(3):1004-1010.

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2021-04-11
  • 最后修改日期:2021-10-27
  • 录用日期:2021-09-22
  • 在线发布日期: 2022-01-27
  • 出版日期:
×
律回春渐,新元肇启|《科学技术与工程》编辑部恭祝新岁!
亟待确认版面费归属稿件,敬请作者关注